The temperature adjustment of the ptc electric heater is based on its own material characteristics, so that this product has a service life much longer than other heaters. Safe and environmentally friendly. The heater body is designed to have multiple levels of heating temperature below 200 degrees Celsius. In any case, the body does not emit red and has a protective isolation layer. Any application does not require asbestos and other heat insulation materials to cool down. It can be used with confidence. Human burns and fire problems.
1. Save power. Comparing electric heating tube and resistance wire heating products, this product relies on the characteristics of the material itself and adjusts its own thermal power output according to the change of the ambient temperature, so it can optimize the heater's power consumption to a minimum, and at the same time, it is a material with high heating efficiency. It also greatly improves the utilization efficiency of electric energy. Rapid heating, automatic temperature control in case of fan failure, long service life of frpp tube, wide voltage range, can be designed between 12V and 380V according to needs, convenient design, can be designed arbitrarily from low power to high power, and the shape can also be designed according to requirements Non-burning, safe and reliable, no redness when PTC heats up, no open flame. In medium and small power heating occasions, the PTC heater has traditional heating components such as constant temperature heating, no open flame, high heat conversion rate, minimal influence by the power supply voltage, and long natural life. Incomparable advantages, the application in electric heating appliances is more and more favored by R&D engineers.
2. The use of ptc electric heater pay attention to that the PTC heating film has the characteristics of automatic constant temperature, and the temperature control system is not required, and the PTC heating film can be directly energized. When the PTC heating film is used to heat liquid (such as water), the PTC heating film will not be damaged after the liquid is dried. If the PTC heating film is used to heat the cold air, the PTC heating film will not be damaged when the air is not supplied. The service life is long, and the service life can reach more than 10 years when used under normal conditions. It works reliably, and uses the internal characteristics of the PTC heater to control the temperature, and it will never over-temperature. The working voltage is very wide: when the working voltage changes twice, the change in surface temperature is very small. When multiple PTC heaters are used together, they should be connected in parallel, not in series.
How much power can the PTC heater save: The PTC heater adopts PTC ceramic fever components and corrugated aluminum strips that are glued at low temperature. This example PTC heater has the advantages of low thermal resistance and high heat exchange efficiency. It is an electric heater with active constant temperature and power saving. Its major feature lies in its safety performance. The ceramic effect of the PTC heater has the advantages of high-temperature PTC heater materials. Under any use situation, there will be no signs of "redness" on the outside of the electric heating tube heater, which may cause burns and fire alarms. Wait for safety hazards. The most obvious feature is: cost saving and long life. The high temperature fan does not need special temperature controllers and thermal resistance thermocouples and other temperature sensors to stop the temperature response and stop the heater. Its temperature regulation is based on its own data characteristics, so that this product has much greater heating than other heating The application life of the device. Safe, green and environmentally friendly PTC heater ceramic effect, high temperature PTC heater material advantages, high temperature PTC heater material technology, PTC heater and iron oxide technology requirements lead-free research on high temperature PTC heater materials PTC heater materials in home appliances, automobiles, etc. constant temperature There are a wide range of applications in heating, temperature and other fields. The advantages of PTC heater ceramic effect and high temperature PTC heater material advantages At present, the annual output of domestic PTC heater elements reaches tens of billions. The lead content in traditional high temperature PTC heater materials (Tc>120°C) is about 30wt%, and the annual lead consumption for PTC heater materials is more than 30,000 tons.